Procom SSU320RHL-B User Manual

1OWNER’S OPERATION AND INSTALLATION MANUALVent Free L.P.& NATURALGAS VENT-FREE STOVEThis appliance may be installed in an aftermarket*,permanently

10Make sure log sits flat on firebox floor.IMPORTANT: Make sure log does notcover any burner ports (see Figure 10).Figure 9 - Checking Gas JointsFigu

11OPERATING HEATERFOR YOUR SAFETYREAD BEFORE LIGHTING A. This appliance is equipped with anignition device which automaticallylights the pilot. Do not

12 Fig 15 - Control boardSETTING TIMER1. AUTO ON:With burner off, press TIMER button.Then press or to change to thescheduled time, then press the

13 TO TURN OFF GAS TO APPLIANCEPush in gas Control Knob slightly andturn clockwise the OFF position. Donot force.When electric power is available an

14Figure 17 - Correct Pilot FlamePatternFigure 18 - Incorrect Pilot Flame PatternBURNER FLAME PATTERNFigure 19 shows a correct

15Figure 24 - Pilot Air Inlet HoleFigure 23 - Burner Primary AirInletMAIN BURNERPeriodically inspect all burner flame holeswith the heater running. Al

16SPECIFICATIONSBtu (Variable) 32,000 32,000Gas Type

17TROUBLESHOOTING WARNING: Make sure thatpower is turn off before proceeding. WARNING: Turn off and let coolbefore servicing. Only a qualifiedser

18TROUBLESHOOTINGContinuedOBSERVED PROBLEMODS/pilot has flame but burner doesnot lightDelayed ignition at burnerBurner backfiring during combustionS

19TROUBLESHOOTINGContinuedREMEDY1. Ventilate room. Stop using odorcausing products while heater isrunning2. Locate and correct all leaks (seeChecking

2Table of ContentsSafety Information-----------------------------------------------------------------------------------------2Product Features-------

20ILLUSTRATEDPARTS BREAKDOWNSSU320RHN-GBSSU320RHN-BSSU320RHN-GSSU320RHN-SSSU320RHL-GBSSU320RHL-BSSU320RHL-GSSU320RHL-SKey No.Part NumberDescriptionQ

21ILLUSTRATEDPARTS BREAKDOWNSSU320RHN-GBSSU320RHN-BSSU320RHN-GSSU320RHN-SSSU320RHL-GBSSU320RHL-BSSU320RHL-GSSU320RHL-SKeyNo.Part NumberDescriptionQTYS

3Keep the appliance area clear andfree from combustible materials,gasoline, and other flammable va-pors and liquids.Carefully supervise young children

4UNPACKING1. Remove top inner pack.2. Tilt carton so that stove is upright.3. Remove protective side packaging.4. Slide stove out of carton.5. Rem

5AIR FOR COMBUSTION AND VENTILATION WARNING: This heatershall not be installed in a confinedspace or unusually tight con-struction unless provisions

6If the actual Btu/Hr used is less than the maximum Btu/Hr the space can support, the space is anunconfined space. You will need no additional fresh

7INSTALLATIONCHECK GAS TYPEBe sure your gas supply is right foryour heater. Otherwise, call dealerwhere you bought the heater for propertype heater.F

8Minimum Wall and Ceiling Clearances(see Figure 4)A. Clearances from outermost point ofstove top to any combustible sidewall should not be less than

9IMPORTANT: Install equipmentshutoff valve in an accessible location.The equipment shutoff valve is for turn-ing on or shutting off the gas to theapp